Replacing Brake Disc Rotor on Kia Sportage?

The details for this task is as follows :-----

Removal & Installation

1. Before servicing the vehicle, refer to the Precautions Section.
2. Raise and safely support the vehicle.
3. Remove the front wheels.
4. Remove the 2 caliper bolts and lift the caliper from the disc.
5. Slide the disc pads off the caliper mounting bracket.
6. Remove the two bolts securing the mounting bracket to the steering knuckle and remove the bracket.
7. Remove the two screws securing the rotor to the hub.
8. Remove the rotor from the hub.

To install:

1. Position the rotor on the hub and secure with the two retaining screws.
2. Using a dial indicator gauge, measure the rotor runout on the out surface of the rotor. Runout should not exceed 0.004 when measured at 4.7 inch from the center of the rotor.
3. Clean the caliper bracket contact surface with a wire brush and lightly coat with assembly lube.
4. Install the anti-rattle clip into the caliper mounting bracket.
5. Position the bracket on the hub with the mounting bolts and tighten the bolts to 17 ft. lbs. (23 Nm).
6. Position the disc pads.
7. Position the caliper over the disc assembly. Install the caliper bolts. Tighten to 13 ft. lbs. (18 Nm).
8. Install the front wheels. Tighten the lug nuts 77 ft. lbs. (104 Nm).
9. Lower the vehicle.
   
   
   

   

   Fig. Caliper mounting bracket and related components
   
   
   
   

   

   Fig. Measure brake rotor runout as shown

This will help.
Thanks.

See below more solved car problems :----

EGR Hoses melting?

http://repairhelpcenter.blogspot.com/2011/12/egr-hoses-melting.html

Location of Freeze Plug on 1998 Ford Expedition?

http://schematicsdiagram.blogspot.com/2011/12/location-of-freeze-plug-on-1998-ford.html

Car Engine Stalls While Driving?

http://schematicsdiagram.blogspot.com/2011/12/car-engine-stalls-while-driving.html

O/D OFF light flashes on Ford Explorer?

http://technoanswers.blogspot.com/2012/01/od-off-light-flashes-on-ford-explorer.html

Engine will not crank after relearning Theft deterrent module?

http://howtobyme.blogspot.com/2012/01/engine-will-not-crank-after-relearning.html

Problems with the rear defroster?

http://schematicsdiagram.blogspot.com/2012/01/problems-with-rear-defroster.html

DIC says "COOLING FAN FAULT"?

http://schematicsdiagram.blogspot.com/2011/12/dic-says-cooling-fan-fault.html

How to remove Front differential?

http://howtobyme.blogspot.com/2012/01/how-to-remove-front-differential.html

Chevy NAV disc slot Location?

http://schematicsdiagram.blogspot.com/2012/01/chevy-nav-disc-slot-location.html

No power due to weak turbo?

http://schematicsdiagram.blogspot.com/2011/12/no-power-due-to-weak-turbo.html

Before purchasing Second hand car?

http://schematicsdiagram.blogspot.com/2011/12/before-purchasing-second-hand-car.html

Purchasing second hand Chevy Lumina?

http://technoanswers.blogspot.com/2012/01/purchasing-second-hand-chevy-lumina.html

Buying second hand 2007 Toyota Corolla sedan?

http://repairhelpcenter.blogspot.com/2012/01/buying-second-hand-2007-toyota-corolla.html

Testing mass air flow sensor?

http://schematicsdiagram.blogspot.com/2011/12/testing-mass-air-flow-sensor.html