How to Remove Exhaust Manifold on Toyota Previa?

The details are as follows :--------

Exhaust Manifold

REMOVAL & INSTALLATION

See Figures 1 through 6

1. Raise and safely support the vehicle.
2. Disconnect the front exhaust pipe from the exhaust manifold by removing the three nuts.

Fig. Fig. 1: Remove the header [pipe attached to the exhaust manifold retaining nuts

3. Remove the 5 nuts and remove the exhaust manifold and gasket.

Fig. Fig. 2: Remove these nuts retaining the exhaust manifold to the engine

Fig. Fig. 3: An extension is necessary to access these nuts on the manifold

Fig. Fig. 4: Scrape any gasket residue from the mating areas with a razor tipped tool

To install:

4. Install the exhaust manifold with a new gasket. Install and tighten the exhaust manifold nuts to 36 Nm (41 Nm). Use a crisscross pattern starting from the center and work outwards.

Fig. Fig. 5: Position a gasket over the studs before the exhaust manifold

Fig. Fig. 6: When installing, place the ,manifold over the studs

5. Connect the front exhaust pipe to the manifold by installing new gaskets and three nuts. Tighten the nuts to 46 ft. lbs. (62 Nm).
6. Lower the vehicle.
7. Start the engine and check for leaks.

This basic details will help.Thanks.

------------------

If you need dis-assembly or replacement instructions for any other auto/car part, or you want to ask question related to your car/truck jeep problem then please leave the comment with your details, so I can provide you the required instructions and solutions.

For more solved car problem,see the list below :----

Where is Radio Fuse located on 2007 Dodge charger?

http://schematicsdiagram.blogspot.com/2011/12/where-is-radio-fuse-located-on-2007.html

Trunk button Not Working on Buick car?

http://schematicsdiagram.blogspot.com/2011/12/trunk-button-not-working-on-buick-car.html

Location of Freeze Plug on 1998 Ford Expedition?

http://schematicsdiagram.blogspot.com/2011/12/location-of-freeze-plug-on-1998-ford.html

Car Engine Stalls While Driving?

http://schematicsdiagram.blogspot.com/2011/12/car-engine-stalls-while-driving.html

Testing mass air flow sensor?

http://schematicsdiagram.blogspot.com/2011/12/testing-mass-air-flow-sensor.html

Where is MAF sensor located on 2000 Ford Expedition?

http://schematicsdiagram.blogspot.com/2011/12/where-is-maf-sensor-located-on-2000.html

Car won't start without hitting the gas pedal?

http://schematicsdiagram.blogspot.com/2011/12/car-wont-start-without-hitting-gas.html

Ford Keyless Remote Fob Reprogramming?

http://schematicsdiagram.blogspot.com/2011/12/ford-keyless-remote-fob-reprogramming.html

1995 Oldsmobile Eighty Eight has bad O2 Sensor?

http://schematicsdiagram.blogspot.com/2011/12/1995-oldsmobile-eighty-eight-has-bad-o2.html

Dual Exhaust on 1996 Chevrolet camaro z28?

http://schematicsdiagram.blogspot.com/2011/12/dual-exhaust-on-1996-chevrolet-camaro.html

How to adjust rpm on 2009 dodge charger SRT8?

http://schematicsdiagram.blogspot.com/2011/12/how-to-adjust-rpm-on-2009-dodge-charger.html

Car takes time to Crank and start?

http://howtobyme.blogspot.com/2011/12/car-takes-time-to-crank-and-start.html

Car jerks while going uphill and Check engine light is ON?

http://schematicsdiagram.blogspot.com/2011/12/car-jerks-while-going-uphill-and-check.html

Car turns over, but only starts, if starter is jumped?

http://schematicsdiagram.blogspot.com/2011/12/car-turns-overbut-only-startsif-starter.html

Service Engine Soon light stays on?

http://schematicsdiagram.blogspot.com/2011/12/service-engine-soon-light-stays-on.html

Gasoline around gas cap?

http://schematicsdiagram.blogspot.com/2011/12/gasoline-around-gas-cap.html

Car will not run after resetting inertia switch on Mercury Mystique?

http://schematicsdiagram.blogspot.com/2011/12/car-will-not-run-after-resetting.html

VAN emits whitish bluish smoke and bad fuel smell from exhaust

http://schematicsdiagram.blogspot.com/2011/12/van-emits-whitish-bluish-smoke-and-bad.html

Car cigarette lighter fuse blows out?

http://schematicsdiagram.blogspot.com/2011/12/car-cigarette-lighter-fuse-blows-out.html

CD MECH ERROR?

http://schematicsdiagram.blogspot.com/2011/12/cd-mech-error.html

Car will not go into 4WD high or 4WD low?

http://schematicsdiagram.blogspot.com/2011/12/car-will-not-go-into-4wd-high-or-4wd.html

Truck is hard to start and Emits smoke while starting?

http://schematicsdiagram.blogspot.com/2011/12/truck-is-hard-to-start-and-emits-smoke.html

Engine cuts out at 3000 RPM?

http://schematicsdiagram.blogspot.com/2011/12/engine-cuts-out-at-3000-rpm.html

Car turns over but will not start, only makes clicking sound?

http://schematicsdiagram.blogspot.com/2011/12/car-turns-over-but-will-not-startonly.html

Catalytic Converter glowing hot?

http://schematicsdiagram.blogspot.com/2011/12/catalytic-converter-glowing-hot.html

After getting car washed, check engine light is ON and key less entry not working, tried reprogramming. Also car shows fuel pressure?

http://schematicsdiagram.blogspot.com/2011/12/after-getting-car-washedcheck-engine.html

Fuel gauge jumps from empty to full?

http://schematicsdiagram.blogspot.com/2011/12/fuel-gauge-jumps-from-empty-to-full.html

Why airbag light flashes 7 times?

http://schematicsdiagram.blogspot.com/2011/12/why-airbag-light-flashes-7-times.html

Passenger side Folding Mirror is not operating?

http://schematicsdiagram.blogspot.com/2011/12/passenger-side-folding-mirror-is-not.html

Very low air output on Chevrolet Trailblazer?

http://howtobyme.blogspot.com/2011/12/very-low-air-output-on-chevrolet.html

After replacing battery, ignition not working?

http://howtobyme.blogspot.com/2011/12/after-replacing-batteryignition-not.html

Where is Fuse box located on 2002 Honda Accord?

http://howtobyme.blogspot.com/2011/12/where-is-fuse-box-located-on-2002-honda.html

 

How to reset Radio code after car battery is died?

http://howtobyme.blogspot.com/2011/12/how-to-reset-radio-code-after-car.html

Car still runs Rough after tune up?

http://howtobyme.blogspot.com/2011/12/car-still-runs-rough-after-tune-up.html

Car cranks, has spark but will not start?

http://howtobyme.blogspot.com/2011/12/car-crankshas-spark-but-will-not-start.html

Cylinder 6 Misfire?

http://howtobyme.blogspot.com/2011/12/cylinder-6-misfire.html

Chevy s-10 blazer 4.3l Spark Plug Firing Order?

http://howtobyme.blogspot.com/2011/12/chevy-s-10-blazer-43l-spark-plug-firing.html

2008 Ford Ranger Shifter Knob Removal?

http://schematicsdiagram.blogspot.com/2011/12/2008-ford-ranger-shifter-knob-removal.html

Erratic idle on car?

http://schematicsdiagram.blogspot.com/2011/12/erratic-idle-on-car.html

Car dies when gas pedal is pressed?

http://schematicsdiagram.blogspot.com/2011/12/car-dies-when-gas-pedal-is-pressed.html

MAF, IAT, MAP and Coolant Level Sensor problem all together on Mazda MPV?

http://schematicsdiagram.blogspot.com/2011/12/maf-iat-map-and-coolant-level-sensor.html

Car Surging?

http://schematicsdiagram.blogspot.com/2011/12/car-surging.html

How to replace a distributor on Chevrolet Camaro?

http://schematicsdiagram.blogspot.com/2011/12/how-to-replace-distributor-on-chevrolet.html

Cadillac Seville Digital Dash Display not working?

http://schematicsdiagram.blogspot.com/2011/12/cadillac-seville-digital-dash-display.html

Can car radio code block Passkey anti theft system ?

http://schematicsdiagram.blogspot.com/2011/12/can-car-radio-code-block-passkey-anti.html

Rear oil seal leaking?

http://schematicsdiagram.blogspot.com/2011/12/rear-oil-seal-leaking.html

Car water leak around the Starter area and Bell Housing?

http://schematicsdiagram.blogspot.com/2011/12/car-water-leak-around-starter-area-and.html

Where are TPS and IAC Located on Ford Escort?

http://schematicsdiagram.blogspot.com/2011/12/where-is-tps-and-iac-located-on-ford.html

Front tires leaning IN?

http://schematicsdiagram.blogspot.com/2011/12/front-tires-leaning-in.html

Where is Vent fan located on Chevrolet Impala?

http://schematicsdiagram.blogspot.com/2011/12/where-is-vent-fan-located-on-chevrolet.html